EDF: new “non-negligible” cracks in two reactors

EDF is facing new challenges in the maintenance of its nuclear plants in France. ASN reported the detection of thermal fatigue cracks in emergency piping in two reactors.

Share:

On Thursday, March 9, 2023, the French nuclear safety authority (ASN) announced that EDF had detected a “non-negligible” defect in a weld on an emergency pipe in two reactors. Inspections have revealed the presence of thermal fatigue cracks on emergency pipes considered sensitive to stress corrosion in reactor 2 of the Penly nuclear power plant and reactor 3 of the Cattenom nuclear power plant. This discovery comes two days after the revelation of a crack of a size never seen before in the Penly 1 reactor.

The crack at Penly 2 is 57 mm long and represents less than 10% of the circumference, with a maximum depth of 12 mm. As for the crack at Cattenom 3, it is 165 mm long (about a quarter of the circumference) with a maximum depth of 4 mm. These defects could potentially disrupt the maintenance schedule of French power plants.

A revised control strategy is being prepared

The phenomenon of “stress corrosion” has been identified since October 2021 on several sites, but generated smaller cracks and on other areas of these pipes. EDF must submit a revised control strategy to the ASN in the next few days. In total, the electric utility will have to check 200 welds in its entire fleet, according to the ASN. This could potentially cause extended reactor outages and raise uncertainties about nuclear production in 2023.

The phenomenon of thermal fatigue

The other crack mentioned by the ASN is not related to stress corrosion, but to thermal fatigue. This phenomenon appears on stainless steels when a part is subjected to temperature variations. Although this phenomenon is “well known and has been monitored for a long time under historical preventive maintenance programs” according to EDF, it was not expected in the area of the pipe where it was discovered, according to ASN.

EDF will have to adapt its maintenance program to include thermal fatigue checks on larger areas. Julien Collet, deputy director general of the ASN, said that this did not change the program of checks in the short term, but that EDF should adjust its maintenance program to include checks on thermal fatigue over larger areas.

In conclusion, the discovery of non-negligible defects in emergency piping in two reactors could have an impact on nuclear production in France in 2023. The necessary verifications could potentially lead to extended shutdowns of the reactors.

Bahrain has concluded a civil nuclear agreement with the United States and formalised a commitment of $17bn in public investments in the US market, further strengthening bilateral cooperation.
Kairos Power has installed the vessel for its third test prototype in Oak Ridge, aiming to validate manufacturing methods for its future Hermes reactor supported by the US Department of Energy.
London and Prague formalise a strategic partnership to develop the nuclear sector, focusing on small modular reactors and industrial cooperation on supply chains.
Experts have broadly approved France’s Cigéo deep nuclear waste repository project, highlighting technical uncertainties that demand stronger guarantees for long-term safety.
Uzbekistan advances its nuclear project by signing a protocol with Hungary for the supply and local assembly of dry cooling systems, expanding its industrial partnerships in the region.
Polskie Elektrownie Jądrowe is asking the European Commission to review its $49bn investment to build Poland’s first nuclear power plant, a step required under the Euratom Treaty before any construction permit can be issued.
The International Atomic Energy Agency mission completed on July 11 warns that the National Nuclear Safety Administration must hire staff to oversee a fleet of 59 reactors in operation and 32 more under construction.
Energoatom signed strategic agreements with Westinghouse and Holtec at the Ukraine Recovery Conference, aiming to establish nuclear fuel production and small modular reactor capabilities in the country.
Tehran agrees to reopen its nuclear facilities to the IAEA, aiming to resume negotiations with Washington, while Moscow pushes for a “zero enrichment” agreement without getting involved in supervision.
TerraPower has selected three new American suppliers for its advanced Natrium nuclear reactor, confirming progress on the project located in Kemmerer, Wyoming, intended to replace a retiring coal-fired power plant.
Energy Exploration Technologies acquires Daytona Lithium, an Australian subsidiary of Pantera Lithium, for AUD40mn ($27mn), bringing its strategic lithium basin footprint in Smackover, USA to nearly 50,000 acres.
The Canadian Nuclear Safety Commission has identified no major barriers to licensing the ARC-100 reactor, announces ARC Clean Technology.
SE Ignalina, the Lithuanian nuclear operator, has signed a memorandum of understanding with French firm Newcleo to explore the integration of small modular reactors (SMRs) using lead-cooled fast reactor (LFR) technology in Lithuania.
Egyptian President Abdel Fattah al-Sisi oversaw the signing of new agreements for the construction of the El Dabaa nuclear power plant, thus strengthening the strategic cooperation between Egypt and Russia.
Vistra Corp receives green light to extend Perry nuclear plant operations in Ohio by 20 years, securing regional electricity supply until 2046 and ensuring operational continuity for all its nuclear reactors in the United States.
EDF will hold a 12.5% stake in the Sizewell C nuclear project in the UK, a €1.3 billion investment announced during Emmanuel Macron’s official visit to London, confirming the strategic nuclear energy alignment between the two countries.
The French Cigéo project, designed to bury the most hazardous radioactive waste deep underground, obtains a crucial technical validation before its final authorization, expected by the end of 2027.
EDF confirms the continuation of its industrial project in Fessenheim for recycling very low-level radioactive metals, a first in France requiring specific regulatory authorizations, following a public debate concluded last February.
NANO Nuclear Energy Inc. formalizes its collaboration with UrAmerica Ltd. to strengthen Argentina’s uranium supply, aiming to secure future nuclear fuel supply chains for the U.S. market.
American companies SHINE Technologies and Standard Nuclear partner to recycle uranium and plutonium, supplying advanced fuel to the nuclear reactor sector and enhancing the national energy security of the United States.